Product ID:VARGLASS SILICONE RUBBER & ES 4400
MSDS Date:06/25/1993
FSC:5970
NIIN:01-282-5858
MSDS Number: BYGZT

Emergency Phone: 315-336-4400

Info Phone: 315-336-4400

Cage: 79074

Telephone: 315-336-4400

Cage: 79074

FIBROUS GLASS

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

SILICONE RUBBER,VINYL,MENTHOL,PHENOL

SILICONE/SLICONES-OSI-O-SI-OSI

LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT RELEVANT.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN. ACUTE- THE
FIBERS FROM THIS PRODUCT ARE MECHANICAL IRRITANTS AND MAY CAUSE
IRRITATION TO EXPOSED AREAS SUCH AS EYES, SKIN AND UPPER
RESPIRATORY TRACTS. ORAL:UNLIKELY TO OCCUR . CHRONIC- NONE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THE FIBERS.

First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYE/SKIN: FLUSH
WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. INHALED: REMOVE TO
FRESH AIR. PROVIDE OXYGEN/CPR IF NEEDED. ORAL: UNLIKELY TO OCCUR.

Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:NOT RELEVANT
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE AT ROOM TEMPERATURES. KEEP OUT
OF REACH OF CHILDREN.
Other Precautions:AVOID INHALATION OF FIBERS. AVOID CONTACT WITH EYES
AND SKIN. WASH THOROUGHLY AFTER HANDLING MATERIAL.

Respiratory Protection:NONE NORMALLY REQUIRED. IN DUSTY SITUATION, A
NIOSH APPROVED AIR SUPPLIED RESPIRATOR OR DUST RESPIRATOR IS
ADVISED.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE AT THE MINIMUM.
Protective Gloves:LEATHER OR COTTON RECOMMENDED
Eye Protection:GOGGLES RECOMMENDED
Other Protective Equipment:EYE WASH STATION, EMERGENCY SHOWER
Work Hygienic Practices:DO NOT PERMIT EATING, DRINKING OR SMOKING NEAR
THIS MATERIAL.
Supplemental Safety and Health

HCC:N1
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:2.54
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:INSOLUBLE
Appearance and Odor:CONTINOUS FILM OF SILICONE RUBBER ON "FIBERGLASS"
BRAID, NO ODOR

Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:CONDITIONS ABOVE 482F (250C) WITHOUT
ADEQUATE VENTILATION
Hazardous Decomposition Products:SMOKE, METHYL AND PHENYL BY-PRODUCTS,
CARBON MONOXIDE, CARBON DIOXIDE
Conditions to Avoid Polymerization:TEMPERATURES ABOVE 464F/240C

Waste Disposal Methods:LANDFILL IS PREFERRED. COMPLY WITH LOCAL, STATE
AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.